vyv_cox
Well-Known Member
Its the lovely triangular phase diagrams on p43 that Nigel should study![]()
Ah, three-component phase diagrams. I remember answering exam questions on them. Couldn't do it now, though
Its the lovely triangular phase diagrams on p43 that Nigel should study![]()
I'm planning on having a go at casting a new Zinc anode for my sail drive. I've collected a bunch of old anodes over the years, some from boat yards.
The problem is, some of them may be Mg rather than Zn [Later] or even Al.
I know the melting point of Mg is 650° C, wheras Zn is 419.5° C. However, I don't have any temperature control, I just blast it until it all melts.
I did consider scraping a sliver off each sample and trying to ignite it, but are there any better methods?
By the way, I'd quite like to do a batch. Does anyone know where I can get a few more kg of Zinc?
In shipping, we normally use two types of anodes: Zinc which yieds 780 Ah and Aluminium which yields 2700Ah. There several specialist firms that manufacture and market these. One of them is Wilson Walton up in the North who have their own foundries and smelting facilities (www.wilsonwalton.com) They might be able to help out with your research.
Ahhh, so it's not an aluminium anode, it's an anode for aluminium, TFT.
A lot of my bits of scrap are attached to bits of steel, so I was looking for a simple test that would positively identify the zinc without having to melt each piece individually, I can then junk the rest.As I said in my previous post - weigh them. Zinc is four times heavier than magnesium! And nearly three times heavier than aluminium. Well, denser actually.
.
Perhaps an acid that would produce a certain coloured salt?
Try a flame test, broadly described in Wikipaedia here.
Thanks Vic.A cannot think of any coloured salts of Zn, Mg or Al.
None of the elements in question produce a coloured flame.
Ah, three-component phase diagrams. I remember answering exam questions on them. Couldn't do it now, though![]()
slightly off topic - is an anode needed at all if no shore power is used and no electrical connection exists between any of the metal hull fittings ?
Fitting anodes has nothing to do with shorepower. If a shorepower system is isnatlled it may cause rapid anode depletion unless certain precautions (viz fitting a galvanic isolator) are taken.
Interconnecting metal fittings may lead to galvanic corrosion. Cathodic protection may help to prevent this but the better solution would be to not interconnect the fittings if there was no reason to do so.
Some metals will naturally corrode at an unacceptable rate, steel for example and cathodic protection can be used to prevent this.
They may be times when a mix of metals cannot easily be avoided. Folding props are a typical example. Anodes can prevent corrosion of the vulnerable components.
In some cases there is no sound reason to fit anodes.
I used to crew a Westerly Berwick. It had no anodes and it still does not. There is no significant corrosion. It has all the original skin fittings and seacocks and the original (fixed 3 bladed) prop on the original shaft.
Perhaps the engine cooling water intake strainer has been replaced. If so its only because the perforated element inside it fell apart due to dezincification.
Thanks, that was pretty much what I thought but keep getting worried by the fact my boat has none - there are a couple of bronze skin fittings and the prop from the outboard but non of these are interconnected internally, no shore power and its going on a swinging mooring. The boat currently has no fittings for an anode but its been in freshwater until now so was just checking as its about to start a new chapter of life on the sea.
99.999% certain the fittings are bronze, the skeg is definitely aluminum-bronze, there is no inboard motor although the outboard sits in a well in the cockpit so is in essence the saildrive but theres no electrical connection to the motor although it does have an alternator this isnt used.
The outboard will almost certainly have an anode. Often set underneath the cavitation plate.
Keep an eye on it and replace when necessary esp if your outboard is permanently mounted with its LU in the water
Of you cannot undo the screw(s) holding it you can through bolt a small one to the underside of the cavitation plate
The manual says there is one but damned if I can find any trace of an old one or anyone selling one that fits; its a 8hp Mariner Saildrive 2-stroke.
You dont say what the serial number is.
Different types of anode have been fitted at different times/to different versions.
Find the relevant diagram of the gearcase at http://www.boats.net/parts/search/Merc2/Mariner/parts.html and you will see the anode .
It should be mentioned in the owners manual which you should be able to find at
http://download.brunswick-marine.com/download/main;jsessionid=105vjo07c1lcd?type=corp if you have mislaid your copy